当前位置:首页 > 全部子站 > 考证 > 驾驶员

Exhaust and Emission Control Systems Emission Control System

来源:长理培训发布时间:2019-04-20 22:06:57

     Several different emission control systems are used to reduce the amount of airpollution produced by the automobile. The following major ones are included:

 

    Positive crankcase ventilation (PCV)

 

    A positive crankcase ventilation system uses engine vacuum to draw blowby gases intothe intake manifold for reburning in the combustion chambers, shown as Fig. 7. 2.

 

    Engine blowby is caused by pressure leakage past the piston rings on the powerstrokes. A small percentage of combustion gases can flow through the ring end gaps or thepiston ring grooves and into the crankcase. If not reburned in the engine,these fumeswould contribute to air pollution if vented to the atmosphere. If not vented from thecrankcase, the gases would build to a point where engine damage would occur.

 

    A PCV system keeps the inside of the engine clean and reduces air pollution. Olderengines use an open PCV system. This system was not sealed and gases could leak outwhen the engine was shut off. These systems have been totally replaced by the closed PCVsystem.

 

    A closed PGV system uses a sealed oil filler cap,a sealed oil dipstick, ventilationhoses,and either a PCB calve or a flow restrictor. The gases are drawn into the engine andare burned. The system stores the gases when the engine is not running.

 

 

 

    Evaporative emissions control systems

 

    The evaporative emissions control (EVAP) system prevents toxic fuel system vaporsfrom entering the atmosphere. As mentioned earlier, gasoline and many of its additivesevaporate easily, especially if exposed to the atmosphere.

 

    When the engine is operating above idle speed,intake manifold vacuum causes thevacuum-operated purge valve to open. This allows gases to flow through the purge lineand causes fresh air to be drawn through the filter at the bottom of the canister. Theincoming fresh air picks up the stored fuel vapors and carries it through the purge line.The vapors enter the intake manifold and are pulled into the combustion chambers forburning.

 

    When the engine is shut off, gasoline slowly evaporates,producing unwanted vapors.These vapors flow through the fuel tank vent line and into the charcoal canister.Theactivated charcoal in the canister absorbs the fuel vapors and holds them until the engine isstarted again.

 

    Fig. 7. 4 illustrates evaporative emission control system operation.

责编:赵紫雯

发表评论(共0条评论)
请自觉遵守互联网相关政策法规,评论内容只代表网友观点,发表审核后显示!

国家电网校园招聘考试直播课程通关班

  • 讲师:刘萍萍 / 谢楠
  • 课时:160h
  • 价格 4580

特色双名师解密新课程高频考点,送国家电网教材讲义,助力一次通关

配套通关班送国网在线题库一套

课程专业名称
讲师
课时
查看课程

国家电网招聘考试录播视频课程

  • 讲师:崔莹莹 / 刘萍萍
  • 课时:180h
  • 价格 3580

特色解密新课程高频考点,免费学习,助力一次通关

配套全套国网视频课程免费学习

课程专业名称
讲师
课时
查看课程
在线题库
面授课程更多>>
图书商城更多>>
在线报名
  • 报考专业:
    *(必填)
  • 姓名:
    *(必填)
  • 手机号码:
    *(必填)
返回顶部